Home > Search By Bike Model > Airhead > Electrical System > Electrical Kits >

EnDuraLast III Alternator Kit 107mm - BMW Airhead 1977-1995 / EnDuraLast
EnDuraLast III Charging System for BMW and Moto Guzzi 1969-1995
 
Alternative Views:


Part #: EDL3-107

The updated complete alternator replaces ALL the components of the Alternator and the rotor removal tool.

The high output design includes a European made stator and rotor with increased electrical output and paired with a modern diode board, and adjustable voltage regulator. Replaces the under performing Bosch charging system with a 107mm outside diameter stator (timing cover side) used on BMW Airhead's from 1976-1995. This EDL3 charging system will reach charging voltage sooner than any other BOSCH style charging system we offer.
Vehicle Manufacturer: BMW
Application: BMW Airhead Models
Make/Model: BMW R60, R65, R75, R80, R100
Model Years: 1977-1995
Manufacturer #:
  • BMW Rotor: 12 31 1 244 642 (240 watt / 17A ) , 12 31 8 002 347 ( 180 watt / 13 A )
  • BMW Stator: 12 31 1 244 641
  • BMW Diode Board: 12 31 1 244 062, 063
  • BMW Voltage Regulator: 12 32 1 244 409
  • Bosch Rotor: 0 124 033 027
  • Bosch Stator: Fits Frame Label # 0 120 340 004, 0 120 340 005, 0 120 340 008
  • Bosch Diode Board: 0 197 002 001, 0 197 002 002, 0 197 002 003
Power Rating: 400 Watts / 28 Amp

Use the fitment table on the APPLICATION TABLE TAB BELOW to identify the correct kit size before ordering. You can measure the inside (timing cover side) and outside (stator frame side) diameter of your stator ring with calipers or use the BOSCH Alternator part number. Further instructions are included in the installation guide to verify the correct kit required.

Some customers report increased component failure when use of LITHIUM Style batteries. These batteries are not recommended or supported for warranty replacement of components. Conventional wet acid or sealed AGM (Absorbed Glass Mat) batteries are known to work well with all conventional charging systems. See our LITHIUM specific alternator
EDL4Li for this alternative.

Review the Installation Guide,
HERE.

See article in HOW-TO section of Motorcycle Classics Magazine detailing the installation on a BMW /5 Airhead,
HERE.

Brand :
EME Price $450.00
BUY NOW $425.00
You save $25.00!

Quantity in Stock:16
Part #: EDL3-107
Qty:

Description
Application Table
 
Alternator Rotor
  • Designed to replace the original Bosch Rotor with modern EnDuraLast technology
  • OEM Iron Claw Poles, ETP Copper Wire, Nylon bobbin, double resin coating for insulation protection.
  • Computer balanced for reduced high engine RPM vibration reduction.
  • Special resin soaking of coil increases life expectancy at high operating temperatures and engine RPM speed
  • European made of premium components
Alternator Stator
  • Timing Cover Side OD: 107 mm
  • Stator Frame OD: 107.5 mm
  • Inside Diameter: 74 mm
  • European made of premium components and precision machined in USA.
Alternator Stator Frame
  • New cast frame with precision machining.
  • Exact replica of original alternator cover and interchangeable.
  • New clean terminals.
  • New brush holder and brushes.
Diode Board / Rectifier
  • Replaces original design with modern technology.
  • 52 heat sink fins, more surface area = increased heat dissipation.
  • Connections use high temperature solder.
Adjustable Voltage Regulator - 14.3 Volts
  • Can be adjusted to higher voltage, with voltage regulation adjustment guide.
  • Set at 14.3 Volt trim setting; Adjustable voltage setting allows for optimizing the correct voltage for lower RPM urban operation.
  • Must be used with caution as over charging with higher voltage setting will damage a battery.
  • Metal housing with potted electrical components.
  • Direct fitment in stock location.
Tools and Fasteners
  • Includes specialized tool for removing the original alternator rotor.
  • Includes solid diode board mounts to replace the inadequate original rubber mounts (when present).
  • Includes all appropriate mechanical fasteners for a fresh, clean and complete installation.
  • Includes all electrical wires to connect the Diode Board / Rectifier to the Stator Frame.
Installation per Brook Reams
Installation per Cognito Moto

Related Products
Digital Ignition System - BMW Airhead with BOSCH Alternator / EnDuraLast & Sachse Starter - BMW Airhead 9-Tooth 1977-onwards, Replaces VALEO D6RA7, D6RA15; 12 41 9 062 425 / EnDuraLast
BUY NOW $299.99

Add
BUY NOW $119.00

Add
BMW airhead electronic ignition system; bmw airhead digital ignition system; airhead electronic ignition system; airhead digital ignition system; Alpha ignition system; Omega Ignition System; Volker Sachse Electronik 12 41 1 244 670, 12 41 9 062 425 D6RA7, D6RA15, 12411244670, 12411062425, 0 001 157 015, 0 001 157 023, 0001157015, 0001157023, D6RA15, D6RA7, D6RA15 replacement starer, D6RA15 starter, D6ra7 replacement starter, D6RA7 starter, r100