Home > Airhead > Electrical System > Electrical Kits >

EnDuraLast I Alternator Kit 107mm - BMW Airhead 1977-1995 / EnDuraLast
BMW, BMW AIRHEAD. BMW R60, R65, R75, R80, R90, R100, Moto Guzzi, BOSCH ALTERNATOR rotor BMW R , 12311244642,12311244062, 12311244063, 12311357498, 0197002001, 0197002001, 0197002002, 0197002003, 12 31 1 244 062, 12 31 1 244 063, 12 31 1 357 498, 0 197 002
 
Alternative Views:


Part #: EDL1-107

Complete Stock Alternator. Includes all components from the timing chain cover out for a complete replacement of the entire charging system.
This Charging System comes with a 107mm outside diameter stator (timing cover side) and stator frame side outside diameter is 107.5mm.

Vehicle Manufacturer: BMW
Application: BMW Airhead Models
Make/Model: BMW R60, R65, R75, R80, R90, R100
Model Years: 1977 - 1995
Manufacturer #:
  • BMW Rotor: 12 31 1 244 642 (240 watt / 17A ) , 12 31 8 002 347 ( 180 watt / 13 A )
  • BMW Stator: 12 31 1 244 641
  • BMW Diode Board: 12 31 1 244 062, 063
  • BMW Voltage Regulator: 12 32 1 244 409
  • Bosch Rotor: 0 124 033 027
  • Bosch Stator: Fits Frame Label # 0 120 340 004, 0 120 340 005, 0 120 340 008
  • Bosch Diode Board: 0 197 002 001, 0 197 002 002, 0 197 002 003
  • Bosch Voltage Regulator: N/A

Use the fitment table on the APPLICATION TABLE TAB BELOW to identify the correct kit size before ordering. You can measure the inside (timing cover side) and outside (stator frame side) diameter of your stator ring with calipers or use the BOSCH Alternator part number. Further instructions are included in the installation guide to verify the correct kit required.

Some customers report increased component failure when use of LITHIUM Style batteries. These batteries are not recommended or supported for warranty replacement of components. Conventional wet acid or sealed AGM (Absorbed Glass Mat) batteries are known to work well with all conventional charging systems. See our LITHIUM specific alternator
EDL4Li for this alternative.

Review the Installation Guide,
HERE.

Brand :

BMW List Price $1,139.57
EME Price $579.95
BUY NOW $299.00
You save $840.57!

Quantity in Stock:(Out of Stock)
Part #: EDL1-107
Quantity:

Description
Application Table
 
Alternator Rotor
  • Designed to replace the original Bosch Rotor with modern EnDuraLast technology
  • OEM Iron Claw Poles, ETP Copper Wire, Nylon bobbin, double resin coating for insulation protection.
  • Computer balanced for reduced high engine RPM vibration reduction.
  • Special resin soaking of coil increases life expectancy at high operating temperatures and engine RPM speed
  • European made of premium components
Alternator Stator
  • Timing Cover Side OD: 107 mm
  • Stator Frame OD: 107.5 mm
  • Inside Diameter: 74 mm
  • European made of premium components and precision machined in USA.
Alternator Stator Frame
  • New cast frame with precision machining.
  • Exact replica of original alternator cover and interchangeable.
  • New clean terminals.
  • New brush holder and brushes.
Diode Board / Rectifier
  • Replaces original design with modern technology.
  • Connections use high temperature solder.
  • 60 Amp diodes / compared to the stock which is 50 amps
Voltage Regulator
  • Pre set to14.3 Volt trim.
  • Metal housing with potted electrical components.
  • Direct fitment in stock location.
Tools and Fasteners
  • Includes specialized tool for removing the original alternator rotor.
  • Includes solid diode board mounts to replace the inadequate original rubber mounts (when present).
  • Includes all appropriate mechanical fasteners for a fresh, clean and complete installation.
  • Includes all electrical wires to connect the Diode Board / Rectifier to the Stator Frame.
Installation detailed by Brook Reams.