Home > Airhead >

450w Charging System Kit ( 32 Amps ) 105mm Stator - BMW R Airhead & Moto Guzzi / EnDuraLast
Moto Guzzi 450 watt charging system, Airhead 450 watt charging system, 450 watt charging system, airhead charging system, bmw airhead charging system, Moto guzzi charging system, EnDuraLast Charging System, Omega Charging System, omega 450 watt charging
 
Alternative Views:


Part #: EDL450-ALTKIT105

The Ultimate Alternator Charging Kit for your BMW 2 Valve AIRHEAD and MOTO GUZZI with a BOSCH alternator. A simple modern design with fewer components and includes all the installation components to update your under performing BOSCH system. Featuring a permanent magnet rotor which eliminates the brushes and possible rotor failure. The Hi-Output Stator produces significant AC voltage at lower RPM's than the original system and incrementally increases output with higher RPM's. The Combined Voltage Regulator / Rectifier eliminates the two most vulnerable failure items of the BOSCH system, the diode board and voltage regulator.

With correct installation reliability and confidence can be restored to your BMW's charging system - see
Installation Instructions on the preparation of your vehicle and installation of the EnDuraLast Charging System in a step-by-step easy to understand manner. The high amperage output of this system at low engine RPM's allows use of additional lighting, heating and other accessories.
Install this Charging System upgrade NOW for the FINAL improvement to your Charging System!

Vehicle Manufacturer: BMW, MOTO GUZZI and Benelli Sei 750cc
Application: Retrofits ALL Moto Guzzi 1973-95 with Bosch or Saprisa Alternator (AC) Charging System and BMW R 1970-76 with a 105mm stator. Also fits Benelli Sei 6 cylindar 750cc
Make/Model: MOTO GUZZI and BMW : Model 247, Airhead
Model Years: Moto Guzzi - ALL 1973-95 with Bosch or Saprisa Alternator (AC) Charging System, Benelli Sei 750cc and BMW /5, /6 and R90S models only.
Power Rating: 450 Watts @ 14 Volts = 32 Amps

(refer to "Technical Specs" Tab for more specific application information)

NOTE: Not Compatible with lithium iron batteries. A small percentage of customers report use of dry cell batteries with greater internal resistance can cause components to overheat when attempting to push charging voltage to the battery. We recommend conventional wet acid or sealed AGM batteries.

Brand :

EME Price $499.00

Part #: EDL450-ALTKIT105


BMW Rotor Oil Seal [Add $8.25]

MGSeal-840:
Moto Guzzi Rotor Oil Seal [Add $7.95]

Qty:  
Description
Application Table
 
  • Original Equipment, New, Modern charging technology updates the BMW R Airhead original, under-performing 20 amp (max) alternator and rectifier.
  • The critically important higher amperage output of this system at low engine RPM's allows use of lighting, heating and other accessories to be used without discharging the battery or overloading the original charging system.
  • High-tech permanent magnet rotor will never overheat and short out. Brushless design eliminates worn out rotor slip rings and brushes.
  • Eliminates "burnt out warning light" no-charge condition of Bosch systems
  • Combination electronic voltage regulator /rectifier housed in finned cast-aluminum housing which mounts remotely for increased cooling and reliability (Pt # EDL450-VoltRect). which replaces the diode board and voltage regulator.
  • Bolts right on and wires up simply.
  • Original alternator/engine cover fits over the alternator with no alterations required.
  • Designed and manufactured to modern OEM specifications.
  • For ALL Moto Guzzi 1973-95 with Bosch or Saprisa Alternator (AC) Charging System, see Part # EDL450-AltKit105
  • For BMW 1970-1976 w/105mm stator frame use Pt # EDL450-ALTKIT105
  • The Total Maximum Rating of the system is 32 Amps or 450 Watts with a smooth measured increase in power:

29 Amps / 400 Watts @ 5000 RPM
25 Amps / 350 Watts @ 3000 RPM
20 Amps / 280 Watts @ 2000 RPM


We strongly recommend the replacement of the Oil Seal when you replace the Rotor:
Use our Part Number BMWSeal-011

For your crank mounted fully Digital Ignition System for BMW Airheads with this charging system:
See EDL-IGNS

Great story from Pipeburn.com check it out here
Kevils-Speed-Shop
EnDuraLast EDL450-AltKit Installation on a Moto Guzzi

Related Products
Sensing Voltage Modification Installation Kit - BMW R Airhead / EnDuraLast Digital Ignition System - BMW R Airhead with EDL-450 Alternator / Sachse Oil Seal - Moto Guzzi; 904 028 40 / EnDuraLast Electronic Voltage Regulator & Rectifier Combination - Ducati & Moto Guzzi / Ducati Energia
EME Price $22.50

Add
BUY NOW $343.00

Add
EME Price $7.99

Add
EME Price $139.00

Add
edl450,sensing wire BMW airhead electronic ignition system, bmw airhead digital ignition system, airhead electronic ignition system, airhead digital ignition system, electrical ignition system, bmw r, bmw r50, crank mounted ignition system for bmw, bmw motorcycle ignition Moto Guzzi Oil seal; Replacement oil seals; Moto guzzi replacement oil seal; Moto guzzi seal; Saprisa rotor seal; Alternator Oil seal; 904 028 40; 90402840; saprisa oil seal; moto guzzi alternator oil seal 37703805, 363701, 343637, 343629, 343648 Ducati Energia Voltage Regulator Rectifier combination, Moto Guzzi Voltage Regulator, Moto Guzzi voltage rectifier, Moto Guzzi voltage regulator rectifier combination, 1299100A, 12 99 100A, 1233062, 12 33 062